US EPA

1673385 

Journal Article 

ALUMINA SUPPORTED MANGANESE OXIDES FOR THE LOW-TEMPERATURE SELECTIVE CATALYTIC REDUCTION OF NITRIC-OXIDE WITH AMMONIA 

Singoredjo, L; Korver, R; Kapteijn, F; Moulijn, J 

1992 

Yes 

Applied Catalysis B: Environmental
ISSN: 0926-3373 

1 

4 

297-316 

10.1016/0926-3373(92)80055-5 

WOS:A1992KD64300006 

Alumina supported manganese oxides exhibit a high and selective activity for the catalytic reduction of nitric oxide with ammonia (SCR) between 385 and 575 K. Samples with 3-15 wt.-% manganese were studied at space velocities between 22 000-116 000 h-1 and at standard conditions of 500 ppm NO, 550 ppm NH3 and 2% O2. Manganese acetate results in a better dispersion of the manganese oxide on the support and a higher specific catalyst activity than manganese nitrate as precursor, for which crystalline structures could be detected. Temperature-programmed reduction revealed that acetate yields Mn2O3 and nitrate mainly MnO2 on the gamma-alumina support. The nitric oxide conversion per amount of manganese is fairly independent of the loading for the catalysts prepared from each precursor. The use of (NH3)-N-15 reveals that it reacts in a 1:1 molar ratio with nitric oxide towards (NN)-N-15 and/or (NNO)-N-15. The SCR activity (to nitrogen) is strongly dependent on the oxygen partial pressure, whereas water inhibits reversibly. Lattice oxygen of the catalyst is not able to maintain the SCR reaction in the absence of oxygen. The nitrous oxide formation is independent of the oxygen partial pressure, but increases with increasing manganese loading and with temperature, resulting in lower selectivities for nitrogen formation. The nitrogen and nitrous oxide formation probably occur at different sites. Above 525 K (NH3)-N-15 oxidation occurs, yielding mainly (N2O)-N-15 and (NO)-N-15, depending on the temperature. The nitrous oxide is not further reduced by ammonia over this type of catalyst. The addition of tungsten to the catalyst increases the selectivity for nitrogen considerably. The stability of the ex-acetate catalyst is good, for at least 600 h the activity remained constant. The catalysts are sensitive towards sulphur dioxide, the exacetate catalysts the least, due to the strong interaction with the alumina support, as is revealed by TPR. 

ALUMINA; MANGANESE OXIDE; NITRIC OXIDE; SELECTIVE CATALYTIC REDUCTION