Health & Environmental Research Online (HERO)


Print Feedback Export to File
1711315 
Journal Article 
Recovery of anhydrous Na2SO4 from SO2-scrubbing liquor by extractive crystallization: Liquid-liquid equilibria for aqueous solutions of sodium carbonate, sulfate, and/or sulfite plus acetone, 2-propanol, or tert-butyl alcohol 
Lynn, S; Schiozer, AL; Jaecksch, WL; Cos, R; Prausnitz, JM 
1996 
Yes 
Industrial and Engineering Chemistry Research
ISSN: 0888-5885
EISSN: 1520-5045 
35 
11 
4236-4245 
WOS:A1996VR70500049 
Sodium carbonate is a superior scrubbing agent for removing SO2 from combustion gases, but the resulting sodium sulfate (or sulfite) must be recovered for environmental reasons. Recovery by evaporative crystallization is energy-intensive; extractive crystallization (described below) provides an attractive alternative when technically feasible. Liquid/liquid equilibrium data were determined for two-phase mixtures containing aqueous solutions of sodium carbonate, sulfate, or sulfite and a polar organic solvent: acetone, 2-propanol, and 2-methylpropan-2-ol (i.e., tert-butyl alcohol). In the salt-saturated two-phase region, data were obtained between the lower consolute temperature and 60 degrees C (50 degrees C for acetone). Data were also obtained at 35 degrees C for liquid/liquid systems that were subsaturated with their respective salts and for liquid/liquid systems with overall molar ratios of sodium sulfite/sodium sulfate fixed at 25/75, 50/50, and 75/25. In the latter systems, it was found that the sulfite/sulfate ratios in the organic and aqueous phases were the same; i.e., there is no selectivity by these solvents for one salt relative to the other. The data show that any one of these solvents can be used to extract water from a concentrated solution of either sodium sulfite or sodium sulfate in a countercurrent extractor at 35 degrees C, causing the anhydrous salt to crystallize. The wet solvent can be dried for recycle in a similar countercurrent operation at 35 degrees C, using a saturated solution of Na2CO3 as the drying agent. The number of moles of carbonate required for drying does not exceed the number of moles of sulfite-plus-sulfate precipitated. The process energy is about 10% of that required for single-stage evaporative crystallization of the same liquor.